The Birkin

The Birkin
The finished article

Monday, May 21, 2007

Gee, it's very err, green, isn't it?

Finally got to see the car, and yes, it's extremely green at this stage. Overly green, in fact. But I guess you could expect that, as there's nothing else on the body and nothing breaking up the colour. However, there's a really nice movement of the light in the paint, it keeps changing colour depending on where you stand and how the light falls - not quite Harlequin paint, but close. I must admit seeing it for the first time, it wasn't exactly love at first sight, but it's growing on me.

So ignoring a series of barbed comments and outright insults, I finally got to start putting things on the car.

And the change was immediate - as soon as you start breaking the lines with simple things like the rubber strips for the rear arches, and the beading for the suspension holes, it starts to break up the block colours and give the car a little more definition, which was lucky.

So, to the first task - could have a done a few things like the differential, wiring loom or front suspension, but I wanted to see what the front end looked like with all the chrome, so tackled that first. And learnt a few lessons:
  1. Don't bolt everything up tight until near the end, otherwise things won't fit. It's a kit car, not a piece of absolute precision engineering, so things need to wiggle a bit sometimes to fit
  2. Actually stop and think occaisionally
  3. Use other cars (and other people) to check what you've done
  4. Don't be afraid to hit it with a hammer (still working on this one)
  5. Turn the nut, not the bolt.

I put the steering rack in, torqued it all up to the recommended 28Nm, looked at my handiwork then realised that I needed to undo it all to put in the other bits that sit under the bolt heads. Then threaded a screw taking it all off again. Fine, probably about 1.5 hours wasted there, but the steering rack is in, and lesson 1, 2 and 3 learnt.

Then, putting the front wishbones on required a bit more force (lesson 4). Then I discovered I'd put one of the upper wishbones on back to front (re-learn lesson 2 and 3).

All up, 8 hours of work netted the rubber strips back on the car, steering rack and associated equipment bolted in, and upper and lower wishbones installed. And let me tell you, with the chroming and everything, it looks bloody good. Even got a few comments that already it looked a lot better now than it did in the morning.

We also tied the lower wishbones to the upper to keep them from hanging off the car, and we used bright red wire which also looks damn good against the green (the colour, not the wire). I think I might look to add some subtle red somewhere in the build as a contrasting colour - perhaps paint the uprights red? Not sure, want it to be subtle (as it's an extremely strong contrast) but there.

Pretty damn happy now that it's all started, I just hope I get better at it because if I keep building it the way I did on Saturday it'll take 12 months and will fall apart. Hopefully I'll actually figure out how to use the tools at some point ;-)

Oh yes, and photos. Turns out my camera phone photos look terrible, and I'm away now for two weeks, so you'll have to hang on a little longer. I'm thinking of buying a new camera anyway.

Tuesday, May 15, 2007

It's back!

Unfortunately, I'm not. I'm still in Melbourne, doing my weekly 7000km round trip to work on the car on Saturday.

Frank has the car back in the workshop - his comment is that no-one that has seen it so far likes it. I haven't seen it, but I'm prepared to give it the benefit of the doubt ;-) I think it probably looks extremely green at the moment, as it's just a painted shell. Once I get the interior, seats, suspension etc onto it, it will break the colour up a little more.

Personally, I can't wait to see it, and finally get some a) photo's and b) actual visible progress made on the car.

In honour of the completion of the paint job, you'll note that I've changed the colour scheme on the blog. Looking at it, I'm not sure whether I like it, but we'll see if it grows on me.

Tuesday, May 8, 2007

1000+ views!

So, I note today that my little page impression counter has topped 1000 - OK, probably 100 of those are mine, however that's still quite a few people.....thanks to everyone who's reading this, hope it's of interest, and please feel free to leave comments, even if it is to tell me I'm soft in the head for painting my car green......